Article by
Dale Toalston
ASE Certified Technician
OBD-II Trouble Code Technical Description
Evaporative Emissions System - Small leak detected
What does that mean?
This diagnostic trouble code (DTC) is a generic powertrain code, which means that it applies to OBD-II equipped vehicles. Although generic, the specific repair steps may vary depending on make/model.
The Powertrain Control Module (PCM) at different times performs various testson the EVAP system. OBD II Enhanced EVAP systems are in place to keep fuel tankvapors from venting into the atmosphere, and instead purges them into the engineto be burned.
Regular pressure tests are conducted by the PCM to monitor thesealed system for leaks. The PCM monitors the EVAP system pressure by watchingthe fuel tank pressure (FTP) sensor. When the sensor indicates a small leakin the EVAP system, this code is set.
Related evaporative emission trouble codes include P0450, P0451, P0452, P0453, P0454, P0455, P0457, P0458, and P0459.
Potential Symptoms
There will likely be no noticeable symptoms other than the Malfunction IndicatorLamp (MIL). This is because the EVAP system is a closed system and only controlsfuel tank vapors, not engine management.
Causes
Usually this P0456 code is caused by an incorrect or faulty gas cap. Fillingthe fuel tank with the engine running could conceivable cause this code as wellor if the cap wasn't properly tightened. Any of the following could also bethe cause:
- A small leak in any of the EVAP hoses or fuel tank hoses
- A small leak in the purge valve or vent valve
- The EVAP Canister may be leaking
Possible Solutions
First, using a scan tool activate the vent solenoid, sealing the system. Thenmonitor the fuel tank pressure(FTP) sensor.
If the system is sealing properly, the number will stay consistent.If is isn't, the pressure sensor will show that as well.
If the system slowlyleaks, use a smoke machine and watch for smoke exiting the system at any EVAPcomponent. Any where there is smoke exiting the system, that is the faulty component.Do not pressurize the EVAP system with air pressure. Doing so can damage thepurge and vent solenoids in the system.
Other EVAP DTCs: P0440 - P0441 - P0442 - P0443 - P0444 - P0445 - P0446 - P0447 - P0448 - P0449 - P0452 - P0453 - P0455
Related DTC Discussions
Register now to ask a question (free)
- 01 Caravan with P0456 code
01 Caravan with 3.1 engine, 65K miles, gives P0456 code (evap system very small leak). What should I look for and in what order? Thanks for any feedback.Bob... - Check Engine Light 2015 Ram 2500 P0456
4 times the check engine light has come on, Feb Apr May and now June. Took to dealership each time. In Feb they said the code was PO456 but couldn't find a problem. In Apr they installed Detector Evaporative System and Seal vapor Canister and replaced faulty ESIM assembly. In May they replaced the g... - Dodge Caravan 2003 P1684 P0442 P0455 P0456
Check engine light came on a couple of weeks ago. At first it was just the battery code P1684 and the small evap code P0442. Now the other two codes are showing as well. What are the chances that this is only a gas cap issue? I just replaced the cap but have not driven it yet. Since I am getting al... - P0456 2002 D0odge Grand Caravan Sport, 59,000 miles
Hello,I've got an active check engine light with code PO456. Where should I start? I'm in California and was also wondering if the Evap. system is under an extended Federal warranty? If, so, I'll just take it to the dealer. If not, where should I start? I'm a heavy diesel bus tech., so I'm no... - Code P0456 02 Dodge Dakota
i had code 0456- small evap leak detected- on 02 4.7 dakota. i replaced the fuel cap with after market stant and check engine light came on after about a week. i had a scan done and it showed no problems detected. so they cleared the code for me. about 4 days later. the check engine light came on a... - CODE P0456 SMALL EVAP LEAK, 2012 2500 DODGE TRUCK
The check engine light came on and the auto technician said the OBD code was an evap leak..probably a leaking leaky gas cap. took to the mechanic and was told that I needed a new gas tank (installed for $1200.00) would be to take care of the problem. It doesn't sound right that I would need a whol...
Love my Sienna but it came up with 420 & 456 codes right before my inspection date. Replaced gas cap & my mechanic took a quick look at evap lines. Nothing looked bad. :oops: Also tried a can of Cataclean and when that didn’t work replaced bank 1 catalytic converter. Still get both code...- 2010 HYUNDAI GENESIS COUPE - CODE P0456 - EMM CTRL SYS LEAK
Hoping someone can help. My engine light came on a few days ago and someone I work with was able to get the CODE P0456 from his device showing Emission Control Systems Leak (very small). Ever since the engine light came on my car doesn't start up right away. When I turn the key it just shows all t... - 2003 Dodge Caravan P0456
I have an '03 Dodge Grand Caravan with the 3.3 V6 and 92K on the odometer. I am the original owner and have done nothing but routine oil changes and maintainence since buying it new. I just had the Check Engine Light come on for the first time ever so I took it to a local Autozone for help reading t... - P0456, P0440, and P0004 codes on 2006 Dodge Ram 2500
Hi, so I bought a used 2006 Dodge Ram 2500 with a 5.7 L Hemi gas engine about a month ago from a dealership. When I test drove the truck, the check engine light was on and I asked the dealership to run a scan on it so I could decide whether it was still worth buying. They scanned it and said they co...
Need more help with a p0456 code?
If you still need help regarding the P0456 trouble code, please postyour question in our FREE car repair forums.
NOTE: This information is presented for information purposes only.It is not intended as repair advice and we are not responsible for any actionsyou take on any vehicle. All information on this site is copyright protected.
